Maintenance
Home Car Repair
HomeMaintenanceOur Garage
Maintenance

Motoring Guide - Car Maintenance

Basic car maintenance is something every car owner should know. Being able to check the engine oil, the pressure of the tyres and the overall condition of the brakes can save you money, and you won't need to rely on the skills of a mechanic to do everything. All you will need is some basic tools to do the job and of course some time!

Tyres

It's dangerous to drive on tyres that are in poor condition or incorrectly inflated. There's a legal minimum tread depth - crash while driving on illegal tyres and you'll be in trouble with the police and your insurance company.

Pressure

  • Recommended pressure figures are for cold tyres, so you'll get a falsely high reading if you check them after driving for more than a few minutes. Always check tyre pressures cold.
  • Pressure is measured in pounds per square inch (psi) and the right amounts for your car should be listed in your owner's manual. It's common for different amounts to apply to the front and rear tyres.
  • If the amount on the pressure gauge is below that mentioned in your owner's manual, you will need to inflate the tyre. To do this, connect a pump or an air line on a garage forecourt and fill until the right amount is shown on the pressure gauge.
  • If you put too much air into the tyre, depress the pin in the centre of the valve to let some out.
  • Don't forget the pressure of your spare wheel. Your owner's manual should tell you the correct pressure.

Engine oil

If your engine doesn't have the right amount of oil, it could be seriously damaged, sometimes beyond repair.

Checking

  • Check the level at least once a fortnight, if possible when the engine is cold and the car is on a level surface.
  • The dipstick usually sticks out from one side of the engine. On more modern cars it may have a coloured handle: usually red, orange or yellow.
  • Pull the dipstick out and wipe it clean with a rag. Return it to the full extent, pull it out again and check that the oil mark is between the upper and lower limits on the dipstick.

Topping up

  • Make sure you use the right oil, and the same as what's currently in the engine. Your owner's manual will contain these details.
  • Find the oil filler cap - it's usually on the top of the engine and marked 'oil'. Unscrew this carefully and place to one side. Pour in a small amount of new oil and recheck the level with the dipstick. Repeat until the level is about halfway between the maximum and minimum marks on the dipstick.
  • Oil is usually replaced at every service inspection of your car. This is usually once a year or at a maximum of 10,000 miles. Refer to the owners' manual for details.

Exhaust

If the engine sounds rough or you can hear a blowing sound, the exhaust may have a leak. If so, have it checked.

The two emissions tested in the MOT are carbon monoxide (CO) and hydrocarbons (HC). If your car fails on either of these tests you will need to get the problem solved by an authorised service centre.

Shock absorbers

Push down on each corner of the car and then release. If the shock absorbers are working, the corner of the vehicle will quickly settle into its normal position. If it bounces, the shock absorber at that corner will need to be replaced.

Rust

During the MOT your entire car will be examined for rust, especially in structural areas.

Brakes

Pull on the handbrake. If it takes more than a few clicks before it will hold the car on a hill, the cable or rear calipers/drums need by an authorised service centre.

Check that there is no sign of brake fluid in the footwell, whether on the pedal, floor or carpets. This indicates a leakage.

Pump the brake until the pressure builds up and the pedal becomes rigid. Hold your foot on the pedal, feeling for any loss in pressure. If the pedal starts to give way, there is a leak in the system.

  • Likewise if there is a great deal of pedal movement before the brakes begin to bite, the brakes need adjusting.
  • If the pedal feels spongy and braking lacks sharpness, this indicates air in the system. A home brake bleed kit can cure this.

Brakes are crucially important for safety, of course, but complicated to fix. If there's a problem, avoid using your car until an authorised service centre can perform repairs and adjustments. Ask the service centre to check the overall condition of the braking system.

Long-term storage

If your car is going to be left unused for an extended time, there are some simple measures to avoid unnecessary damage:
  • If it's winter, make sure that there is sufficient anti-freeze in the cooling system.
  • Check that your battery is charged. Battery chargers are not expensive and it is worth giving it a boost. If you're going to be away for a long time (and you aren't using an immobiliser/alarm) disconnect the earth strap to prevent the battery losing charge
  • Remove all valuables.
  • Use a car cover to protect it from rain, dust and the habits of birds.
  • Fit a visible steering lock.

Theft prevention

Hundreds of thousands of cars are stolen or broken into each year. There are some simple steps you can take to make sure you're not the next victim:
  • Make sure you keep valuables out of sight when your car is unattended.
  • Always close and lock doors, boot and sunroof. If it hasn't already got one, fit an alarm and immobiliser.
  • Have the windows and windscreen etched with your car's numberplate.
  • Try to leave your car in the most visible location, especially if it's staying there overnight.
  • If your car is fitted with alloy wheels, replace one nut on each wheel with a locking version that needs a special adapter to remove.
  • If the driver's view forward is obscured in any way by windscreen damage, it will need to be repaired or replaced - likewise, if wiper movement is interrupted.
  • Your rear-view mirror should be secure and capable of being adjusted.
  • Your front and rear numberplates must be in good condition, securely fitted and easily read.
  • Under the bonnet there should be a small metal plate bearing the vehicle identification number (VIN). Make sure it's visible.

Summary

Taking care of your car can be a rewarding experience in more than one way, not only will you have the satisfaction of being able to fix things yourself, but you can also take pride in the knowledge you don't have to pay anyone to do it. If you feel you are out of your depth however, do not hesitate to take your car to your local service centre where they can check that your car is safe to go on the road. There are some good books on car maintenance available, but if you prefer the more practical approach enquire at your local schools that may offer evening classes.
 
Brake Changing Tips

It’s a costly business maintaining your brakes. Save your precious pounds by learning this simple DIY technique for changing your brake disc pads.

1. When to change
If you hear a nasty grinding noise every time you stop, waste no time – the pads need changing now.

2. Warning signs
Some cars have warning lights that will tell you when the pads are worn. Others have little viewing holes that let you see the condition of the pads without stripping the brakes right down.

How to change your brake pads

1. Jack the vehicle up; make sure you use an axle to keep the car supported.

2. Unbolt the calipers and swing them free, then remove the clips holding the pads in place and wriggle them out.

3. Inspect the disc. If there's any scoring, you need to get that replaced too.

4. Push the calipers back into place so they can slip back over the new, thicker pads. A G-clamp, applied gently, is ideal for this.

5. However, first take the top off the brake fluid reservoir to give the pressure you create in the system somewhere to escape. Keep a careful eye on the fluid level as you tighten the clamp - overflowing could be dangerous.

6. With the assembly all back together, you can do the same on the other side of the car - only ever replace brake pads and discs in pairs.

Tip: Try to avoid heavy braking for the first hundred miles to let the brakes 'bed in'. They might feel a little snatchy at first but that will soon go.

 

Basic Fluid Level Checks

 

The simple things can help keep a car in good nick between services. Keep your precious motor fine-tuned with these basic fluid level checks:

 

1. Dipstick dos and don’ts
Find the dipstick (see the handbook). Take it out, wipe it with a rag and replace it, then remove it again and check. Top up the oil as necessary, adding a little at a time.

2. Colour alert
If the oil on the dipstick is black and grimy or light brown and emulsified, your engine needs urgent attention. Go to a mechanic as soon as possible.

3. Water marks
If the plastic tank linked to the radiator needs topping up, make sure the engine is cool and then add the right mixture of antifreeze and distilled water (see your handbook).

4. Brake fluid
This is especially important as a leak in the braking system can kill you. When removing the cap from the fluid reservoir (see your car manual), wipe off any dust. Seek help if the fluid level goes up and down or is empty.

5. Other fluids
There are fluid reservoirs for power steering, automatic gearboxes and clutches. If you need to top them up, consult the handbook for the correct fluid to add.

 

Long journey checks

Getting ready to set off on a long journey? Going abroad? Don’t conk out in no-man’s-land - make sure your car’s up to the distance.

1. How's it running?

If your car's only been used for short hops, take it for a blast up the motorway. An hour of fast stuff should blow the cobwebs away - but look out for signs that it's unhappy.

2. Keep it cool

Look underneath the car for leaks. Check the level of coolant in the radiator and watch out for rust. Then tick the engine over for 20 minutes and watch the temperature gauge. If it climbs into the red, consult a mechanic.

3. Filter tips

Take off the air filter cover, remove the element and lose the blockages. Filters don't cost much, so replace it if the blockage is severe. Do the same for the fuel filter.

4. Stay on the level

Check the level and condition of the oil as well as your brake and clutch fluid levels. If they are low, you need to find out where the fluid has gone - so get it checked out>

5. Lighten up

Check your headlamps and tail lights work properly on dipped and main beam; check your indicators and fog lamps and brake lights (get someone to stand behind the car). If you're going overseas, you may need to mask off a section of the headlamps to avoid dazzling.

6. Handle the pressure

Check your manufacturer's handbook for recommended pressures for laden and unladen use and adjust as required. Examine the condition of your tyres too. Replace them if there is wear and tear. Remember, the spare tyre should also be in good condition.

7. Do your homework

Carry your MoT, driver's licence and insurance certificate and make sure none will expire while you're away. Consult your insurer regarding the need for a green card overseas.

8. Be prepared

Every country has different motoring laws. Most want to see a warning triangle and first aid kit, several require a fire extinguisher and a few demand a towrope, as well as spare bulbs. The simple solution: carry the lot.